The Dezign Builds

The Dezign Builds Contact information, map and directions, contact form, opening hours, services, ratings, photos, videos and announcements from The Dezign Builds, Construction Company, Hyderabad.

05/04/2026

CPVC PIPES : SDR 11 vs SDR 13.5

SDR 11: Lower SDR → thicker wall → higher pressure capacity (~20–25 kg/cm²). Suitable for hot water and high-pressure systems.

SDR 13.5: Higher SDR → thinner wall → moderate pressure capacity (~10–16 kg/cm²). Suitable for cold water and normal domestic use.
👉 Key Point: Lower SDR means higher strength and pressure resistance.

02/04/2026

Checking the verticality of a column with plywood (ply) shuttering using a plumb bob.

01/04/2026

Lapping Zone in Column.
As per IS 456:2000, lap splices in columns should not be provided in highly stressed regions.
✅ Recommended Location:
Middle 1/3 height of the column (mid-height zone)
❌ Avoid Lapping At:
Beam-column junctions
Near slab levels
Near footing/top & bottom ends
📐 Additional IS Guidelines:
Lap only up to 50% of bars at one section
Provide staggered laps
Provide closer lateral ties (stirrups) in lap zone
Typical lap length ≈ 50d (tension), 40d (compression) (as per design conditions)
🎯 One-Line Summary
“Column lapping should be done in the middle zone, avoiding joints and high-stress regions, with proper staggering and confinement as per IS 456.”

31/03/2026

Epoxy-coated rebar (often called ECR) is conventional steel reinforcement coated with a thin layer of fusion-bonded epoxy (typically ~175–300 microns thick).

That coating acts as a dielectric barrier, isolating steel from moisture, oxygen, and chlorides—the primary drivers of corrosion.

Rebar corrosion is an electrochemical process. When chlorides pe*****te concrete, they break down the passive oxide layer on steel → corrosion starts → expansion → cracking → spalling.

👉 Epoxy coating interrupts this process by:

Blocking chloride ion ingress

Preventing electrochemical reactions

Reducing corrosion current density

30/03/2026

Anti-termite treatment..

29/03/2026

Epoxy-coated steel is used primarily to provide superior corrosion resistance, significantly extending the lifespan of infrastructure in harsh environments.

28/03/2026

A sunken slab in a bathroom is a structural technique where the floor is cast 200mm–450mm lower than the main floor level. Its primary uses are to conceal plumbing pipes/drainage, prevent leakage into lower rooms, and allow for proper slope creation for wastewater, ensuring a clean, modern look.

27/03/2026

Rebar tensile strength refers to the maximum amount of pulling (tensile) stress that a reinforcing steel bar can withstand before it completely fractures or breaks. While yield strength is the point where the steel begins to deform permanently, tensile strength (or ultimate tensile strength) is the peak stress reached during stretching.

26/03/2026

A drip mould (or drip groove) is a small, functional groove or projection built into the underside of external projections—such as balconies, window sills, and sunshades (chajjas)—to prevent rainwater from flowing back toward the wall. It forces water to drip off by breaking the surface tension, thus preventing dampness, seepage, and plaster damage.

25/03/2026

Damp proof course advantages.

1.Prevents Rising Dampness

2.Protects Wall Strength

3.Stops Paint & Plaster Damage

4.Prevents Fungus & Mold Growth

5.Increases Building Life

6.Improves Indoor Health

7.Cost Effective in Long Run

24/03/2026

Seismic Zones in India (Revised Concept)

🟢 Zone II – Low Risk

Very low probability of earthquakes

Minor shaking, negligible structural damage

🟡 Zone III – Moderate Risk

Moderate earthquakes possible

Light to moderate damage in weak buildings

🟠 Zone IV – High Risk

Strong earthquakes possible

Significant damage if buildings are not designed properly

🔴 Zone V – Very High Risk

Severe earthquakes likely

Major structural damage and collapse risk

🟣 Zone VI – Extreme Risk (Proposed)

Very severe and frequent earthquakes

Highest level of destruction expected

Strict seismic design mandatory

⚠️ Note:

Zone VI is proposed, not officially implemented yet

Current official design still follows Zone II to Zone V

Address

Hyderabad

Website

Alerts

Be the first to know and let us send you an email when The Dezign Builds posts news and promotions. Your email address will not be used for any other purpose, and you can unsubscribe at any time.

Contact The Business

Send a message to The Dezign Builds:

Shortcuts

Share

Category